how to install transmission fluid on a saturn vue 2004

I would prefer using the scan tool but I cannot see a reason why the other method would not work just as well.2003 Saturn Vue transmission problems and more the date of sale. If you had removed 7.5 liters, and you replaced it with 7.5 liters the trans fluid should be at the correct level. Inject the additive, start the engine and shift it as above. Now pour in the first six liters of fluid. So lets say you drain it and get 7.5 liters of fluid out. Get as accurate as possible, no guessing as fluid level in these is somewhat critical. Now measure the amount of fluid using something like a measuring cup. Now after all of that there is a lower tech way that should work just as well. Finally inject the entire contents of the DEX-CVT P/N 22697447 additive into the transmission. If the transmission fluid temperature is 80 C (176 F), add 1.2 liter (1.25 qt) of fluid to the transmission. If the transmission fluid temperature is 60 C (140 F), add 0.95 liter (1.0 qt) of fluid to the transmission. If the transmission fluid temperature is 40 C (104 F), add 0.71 liter (0.75 qt) of fluid to the transmission. If the transmission fluid temperature is 20 C (68 F) or less, add 0.47 liter (0.5 qt) of fluid to the transmission. Now you connect up the scan tool and look at the transmission fluid temperature and add fluid following this table. Once the fluid stops you install the new lower tube drain plug and tighten it to 11 Nm ( 97 Inch lb) If no fluid runs out, add fluid until it starts to run out. If fluid runs out in a steady stream, let it run until it stops. Next go under the vehicle (keep it level, if you are using a jack you need to jack both ends, if ramps use them on both ends, or use a lift) and remove the small drain plug. That circulates the trans fluid around the system.

Shift the trans into reverse for ten seconds, then into drive for another ten seconds. With the vehicle flat and level, add 6 quarts of DEX-CVT fluid. Now install the smaller drain plug finger tight. Now to refill you replace the long tube first, torque it to 20 Nm (15 ft lb). But it is two parts, there is a plug in the middle and a tube that the plug screws into. The drain is located on the trans near the axle. That is because it gets filled by temperature. Next you need a scan tool that can read the transmission temperature. These are not common fluids or universal types, generally they are dealer only items.įluid = Saturn DEX-CVT P/N 22688912 Additive = Saturn DEX-CVT P/N 22697447 Draining it is easy, refilling it is the problem.įirst you need the correct CVT fluid and the CVT additive.

How to install transmission fluid on a saturn vue 2004